高级搜索

水解酸化-改良UASB工艺处理玉米酒精废水

,  ,  ,  ,  , 

downloadPDF

上一篇

下一篇

于鲁冀, 王惠英, 陈涛, 邵玉敏, 孔德芳, 范佳琦. 水解酸化-改良UASB工艺处理玉米酒精废水[J]. 环境工程学报, 2012, 6(11): 3970-3974.
引用本文: 于鲁冀, 王惠英, 陈涛, 邵玉敏, 孔德芳, 范佳琦. 水解酸化-改良UASB工艺处理玉米酒精废水[J]. 环境工程学报, 2012, 6(11): 3970-3974.
shu
Yu Luji, Wang Huiying, Chen Tao, Shao Yumin, Kong Defang, Fan Jiaqi. Treatment of corn alcohol wastewater using hydrolysis acidification-improved UASB[J]. Chinese Journal of Environmental Engineering, 2012, 6(11): 3970-3974.
Citation: Yu Luji, Wang Huiying, Chen Tao, Shao Yumin, Kong Defang, Fan Jiaqi. Treatment of corn alcohol wastewater using hydrolysis acidification-improved UASB[J]. Chinese Journal of Environmental Engineering, 2012, 6(11): 3970-3974.
shu

水解酸化-改良UASB工艺处理玉米酒精废水

  • 1.

    郑州大学水利与环境学院, 郑州 450002

  • 2.

    郑州大学环境技术咨询工程公司, 郑州 450002

  • 3.

    郑州大学环境政策规划评价研究中心, 郑州 450002

  • 4.

    华北水利水电学院环境与市政工程学院

  • 基金项目:

    国家"水体污染控制与治理"科技重大专项(2009ZX07210-002-002)

  • 中图分类号: X703

Treatment of corn alcohol wastewater using hydrolysis acidification-improved UASB

  • 1.

    College of Water Conservancy & Environmental Engineering, Zhengzhou University, Zhengzhou 450002, China

  • 2.

    Zhengzhou University Environmental Technology and Consulting Company, Zhengzhou 450002, China

  • 3.

    Zhengzhou University Research Center for Environmental Policyplanning and Assessment, Zhengzhou 450002, China

  • Fund Project:

  • 摘要: 采用一种新的工艺技术方法即水解酸化-改良UASB工艺处理玉米酒精废水。结果表明,在改良UASB运行60 d顺利启动完成后,进水COD在5 470~7 910 mg/L之间,TN在70~107 mg/L之间,TP在115~187 mg/L之间,SS在864~1 490 mg/L之间的条件下,水解酸化对COD和SS的去除率分别达50%和51%,NH3-N经过水解酸化后升高。改良UASB对COD的去除率达80%,对 NH3-N、TN和TP也有一定去除,去除率分别为 12% 、17%和20%,经过水解酸化及改良UASB处理利于后续好氧处理。
    Abstract: Hydrolysis acidification-improved UASB process was adopted to treat corn alcohol wastewater. The results showed that the removal rates of COD and SS reached 50% and 51%, respectively after the hydrolysis acidification process, when the improved UASB reactor was successfully launched after 60 d operation and the COD, TN, TP and SS concentratinons of the influent water were 5 470~7 910 mg/L, 70~107 mg/L, 115~187 mg/L and 864~1 490 mg/L, respectively; however, NH3-N concentration increased after hydrolysis acidification. Under the same experimental conditions, the removal rate of COD was up to 80% after improved UASB process, NH3-N, TN and TP were also removed partly, and the corresponding removal rates were 12%, 17% and 20%, respectively. Hydrolysis acidification-improved UASB process was beneficial to the subsequent aerobic treatment.
  • 加载中
  • [1] 尤新. 玉米的综合利用及深加工. 北京:中国轻工业出版社, 1993
    [2] 唐受印, 戴友芝, 刘忠义, 等. 食品工业废水处理. 北京:化学工业出版社, 2001
    [3] 贺延龄. 废水的厌氧生物处理. 北京:中国轻工业出版社, 1998
    [4] 张超. 厌氧好氧工艺设计处理酒精生产废水. 污染防治技术, 2006, 19(2): 58-68 Zhang Chao. Application of anaerobic-oxidation process to alcohol wastewater treatment. Pollution Control Technology, 2006, 19(2): 58-68(in Chinese)
    [5] 沈连峰, 田立江, 陈荣平, 等. 酒精废水的处理和综合利用技术. 水处理技术, 2007, 33(8): 68-70 Shen Lianfeng, Tian Lijiang, Chen Rongping, et al. Treatment of alcohol wastewater and comprehensive utilization technology. Technology of Water Treatment, 2007, 33(8): 68-70(in Chinese)
    [6] Rebac S., Ruskova J., Gerbens S., et al. High-rate anaerobic wastewater treatment using the UASB reactor under a wide-range of temperature conditions. Journal of Fermentation and Bioengineering, 1995, 80(5): 499-506
    [7] 孙美琴, 彭超英, 梁多. 水解酸化预处理工艺及应用. 四川环境, 2003, 22(4): 52-55 Sun Meiqin, Peng Chaoying, Liang Duo. The application of hydrolytic-acidification pretreatment process. Sichuan Environment, 2003, 22(4): 52-55(in Chinese)
    [8] 裘湛, 张之源. 高速厌氧反应器处理城市污水的现状与发展. 合肥工业大学学报(自然科学版), 2002, 25(1): 117-122 Qiu Zhan, Zhang Zhiyuan. Present application and development of municipal wastewater treatment by high-rate anaerobic reators. Journal of Hefei University of Technology, 2002, 25(1): 117-122(in Chinese)
    [9] 管锡珺, 郑西来. 现行的UASB反应器的设计问题及改良的可行性. 环境工程, 2004, 22(2): 17-19 Guan Xijun, Zheng Xilai. Desigh problems and modified feasibility of current upflow anaerobic sludge blanket (UASB) reactor. Environmental Engineering, 2004, 22(2): 17-19(in Chinese)
    [10] 匡武, 殷福才, 孙世群, 等. UASB工艺在啤酒废水处理中的应用. 中国给水排水, 2006, 22(16): 62-66 Kuang Wu, Yin Fucai, Sun Shiqun, et al. Application of upflow anaerobic sludge blanket process to a brewery wastewater treatment. China Water & Wastewater, 2006, 22(16): 62-66(in Chinese)
    [11] 黄武. 水解酸化-UASB处理高浓度酿酒废水. 环境工程, 2001, 19(5): 50-51 Huang Wu. Treatment of wine wastewater of high concentration by hydrolytic acidification-UASB. Environmental Engineering, 2001, 19(5): 50-51(in Chinese)
    [12] 沈耀良, 王宝贞. 水解酸化工艺及其应用研究. 哈尔滨建筑大学学报, 1999, 32(6): 35-38 Shen Yaoliang, Wang Baozhen. Hydrolysis-acidogenosis process and its application and study. Journal of Harbin University of C. E. & Architecture, 1999, 32(6): 35-38(in Chinese)
    [13] 严进. 水解酸化-SBR工艺处理味精废水, 环境工程, 2006, 24(6): 29-30 Yan Jin. An experimental study on treatment of monosodium glutamate wastewater by hydrolytic acidification-SBR process. Environmental Engineering, 2006, 24(6): 29-30(in Chinese)
    [14] 王建龙, 彭永臻, 高永青, 等. 强化内源反硝化脱氮及污泥减量化研究. 环境科学, 2008, 29(1): 134-138 Wang Jianlong, Peng Yongzhen, Gao yongqing, et al. Nitrogen removal by enhanced endogenous denitrification with excess activated sludge reduction technology. Environmental Science, 2008, 29(1): 134-138(in Chinese)
    [15] 杨洋, 左剑恶, 沈平, 等. 温度、pH值和有机物对厌氧氨氧化污泥活性的影响. 环境科学, 2006, 27(4): 691-695 Yang Yang, Zuo Jiane, Shen Ping, et al. Influence of temperature, pH value and organic substance on activity of anammox sludge. Environmental Science, 2006, 27(4): 691-695(in Chinese)
    [16] Mulder A., van de Graaf A.A., Robertson L.A., et al. Anaerobic ammonium oxidation discovered in a denitrifying fluidized bed reactor. FEMS Microbiology Ecology, 1995, 16(3): 177-184
    [17] van de Graaf A.A., Mulder A., de Brejn P., et al. Anaerobic oxidation of ammonium is a biologically mediated process. Applied and Environmental Microbiology, 1995, 61(4): 1246-1251
    [18] 陈金荣, 谢丽, 罗刚, 等. 高温CSTR—中温UASB两级厌氧处理木薯酒精废水. 工业水处理, 2011, 31(2): 33-36 Chen Jinrong, Xie Li, Luo Gang, et al. Two-stage anaerobic treatment of cassava ethanol wastewater using thermophilic CSTR and mesophilic UASB. Industrial Water Treatment, 2011, 31(2): 33-36(in Chinese)
    [19] El-Shafai Saber A., El-Gohary Fatma A., Nasr Fayza A., et al. Nutrient recovery from domestic wastewater using a UASB-duckweed ponds system. Bioresource Technology, 2007, 98(4): 798-807
    [20] 丁丽丽, 朱益新, 梁瀚文, 等. 大型UASB系统磷化氢分布及磷平衡研究. 南京大学学报(自然科学), 2005, 41(6): 620-626 Ding Lili, Zhu Yixin, Liang Hanwen, et al. Distribution of phosphine and phosphorus balance in a full-scale UASB system. Journal of Nanjing University (Natural Sciences), 2005, 41(6): 620-626(in Chinese)
  • 加载中
WeChat 点击查看大图
计量
  • 文章访问数:  2237
  • HTML全文浏览数:  1173
  • PDF下载数:  2558
  • 施引文献:  0
出版历程
  • 收稿日期:  2011-11-20
  • 刊出日期:  2012-11-09
于鲁冀, 王惠英, 陈涛, 邵玉敏, 孔德芳, 范佳琦. 水解酸化-改良UASB工艺处理玉米酒精废水[J]. 环境工程学报, 2012, 6(11): 3970-3974.
引用本文: 于鲁冀, 王惠英, 陈涛, 邵玉敏, 孔德芳, 范佳琦. 水解酸化-改良UASB工艺处理玉米酒精废水[J]. 环境工程学报, 2012, 6(11): 3970-3974.
shu
Yu Luji, Wang Huiying, Chen Tao, Shao Yumin, Kong Defang, Fan Jiaqi. Treatment of corn alcohol wastewater using hydrolysis acidification-improved UASB[J]. Chinese Journal of Environmental Engineering, 2012, 6(11): 3970-3974.
Citation: Yu Luji, Wang Huiying, Chen Tao, Shao Yumin, Kong Defang, Fan Jiaqi. Treatment of corn alcohol wastewater using hydrolysis acidification-improved UASB[J]. Chinese Journal of Environmental Engineering, 2012, 6(11): 3970-3974.
shu

水解酸化-改良UASB工艺处理玉米酒精废水

  • 1.  郑州大学水利与环境学院, 郑州 450002
  • 2.  郑州大学环境技术咨询工程公司, 郑州 450002
  • 3.  郑州大学环境政策规划评价研究中心, 郑州 450002
  • 4.  华北水利水电学院环境与市政工程学院
  • 收稿日期:  2011-11-20
基金项目:

国家"水体污染控制与治理"科技重大专项(2009ZX07210-002-002)

摘要: 采用一种新的工艺技术方法即水解酸化-改良UASB工艺处理玉米酒精废水。结果表明,在改良UASB运行60 d顺利启动完成后,进水COD在5 470~7 910 mg/L之间,TN在70~107 mg/L之间,TP在115~187 mg/L之间,SS在864~1 490 mg/L之间的条件下,水解酸化对COD和SS的去除率分别达50%和51%,NH3-N经过水解酸化后升高。改良UASB对COD的去除率达80%,对 NH3-N、TN和TP也有一定去除,去除率分别为 12% 、17%和20%,经过水解酸化及改良UASB处理利于后续好氧处理。

English Abstract

    全文HTML

参考文献 (20)

返回顶部

目录

/

返回文章
返回

Copyright © 2019 中国科学院生态环境研究中心