高级搜索

CaCl2-PAC工艺处理酸性高氟废水

,  ,  ,  ,  , 

downloadPDF

上一篇

下一篇

杜敏, 宁静恒, 杨道武, 房文婷, 雷杰, 刘弟. CaCl2-PAC工艺处理酸性高氟废水[J]. 环境工程学报, 2015, 9(4): 1837-1841. doi: 10.12030/j.cjee.20150451
引用本文: 杜敏, 宁静恒, 杨道武, 房文婷, 雷杰, 刘弟. CaCl2-PAC工艺处理酸性高氟废水[J]. 环境工程学报, 2015, 9(4): 1837-1841. doi: 10.12030/j.cjee.20150451
shu
Du Min, Ning Jingheng, Yang Daowu, Fang Wenting, Lei Jie, Liu Di. Treatment of acidic and highly concentrated fluoride wastewater using calcium chloride-poly aluminum chloride[J]. Chinese Journal of Environmental Engineering, 2015, 9(4): 1837-1841. doi: 10.12030/j.cjee.20150451
Citation: Du Min, Ning Jingheng, Yang Daowu, Fang Wenting, Lei Jie, Liu Di. Treatment of acidic and highly concentrated fluoride wastewater using calcium chloride-poly aluminum chloride[J]. Chinese Journal of Environmental Engineering, 2015, 9(4): 1837-1841. doi: 10.12030/j.cjee.20150451
shu

CaCl2-PAC工艺处理酸性高氟废水

  • 1.

    长沙理工大学化学与生物工程学院, 长沙 410114

  • 基金项目:

    湖南省重大科技专项资助项目(2009FJ1009-3)

    湖南省科技项目资助项目(2008GK3063,2010GK2043)

  • 中图分类号: X703

Treatment of acidic and highly concentrated fluoride wastewater using calcium chloride-poly aluminum chloride

  • 1.

    School of Chemistry and Biological Engineering, Changsha University of Science and Technology, Changsha 410114 , China

  • Fund Project:

  • 摘要: 以湖南某氟化盐厂排放的酸性高氟废水为研究对象,提出CaCl2-PAC处理酸性高氟废水新工艺,确定了最佳工艺条件,并对比了晶种添加前后对除氟效果、沉渣含水率的影响及沉渣中氟化钙的纯度;结果表明:在钙盐沉淀阶段, pH≈9, n (Ca/F)=0.75,搅拌45 min、沉降90 min;在絮凝沉淀阶段,pH≈7.5,PAC投加量为350 mg/L,最后出水氟离子浓度可降至10 mg/L以下,达到了《污水综合排放标准(GB8978-1996)》的一级标准。在钙盐沉淀阶段按照10 g/L添加大颗粒氟化钙后,氟去除率进一步提高,处理后所得的沉渣氟化钙纯度可达到85%,沉渣含水率较晶种添加前降低20%,有利于实现高效除氟和氟化钙的回收利用。
    Abstract: A new removal process by using calcium chloride together with poly aluminum chloride (PAC) was reported for the treatment of the acidic and highly concentrated fluoride wastewater which was discharged from a fluoride salt plant in Hunan.The optimum process conditions were determined.Compatative studies were carried out on the fluoride-removal effect as well as the moisture content and the CaF2 purity of the sediment,with or without adding the seed crystal of CaF2.Results showed that (i) in the first stage of precipitation with calcium salt,the optimum conditions were as follows:the pH was adjusted around 9 using a calcium hydroxide solution,and the dosage of the 5% calcium chloride solution was determined according to the mole number of CaF2 (herein,n=0.75),stirring for 45 min and precipitating for 90 min,and then (ii) in the second stage of flocculation with PAC,the optimum conditions were as follows:the pH was around 7.5 and the dosage of PAC was 350 mg/L.Then,the residual mass concentration of fluoride ion in the wastewater could be controlled under 10 mg/L,meeting the first class of Integrated Wastewater Discharge Standard (GB-8978-1996).Besides,in the first stage by adding the seed crystal of CaF2 with a dosage of 10 g/L,in the sediment the moisture content was found to decrease by 20% while the CaF2 purity increased up to 85%,which indicates a better fluoride-removal effect and benefits for CaF2 recovery and reuse.
  • 加载中
  • [1] 蒋为,杨仁斌,桂腾杰,等.消石灰处理含氟废水试验研究.湖南农业科学,2009,(4):79-81 Jiang Wei,Yang Renbin,Gui Tengjie,et al.Study on removal of fluoride from wastewater by calcium hydroxide.Hunan Agricultural Sciences,2009,(4):79-81(in Chinese)
    [2] 刘鸿仪,刘立群,徐九根,等.石灰——硫酸铝——聚丙烯酰胺法处理含氟废水的试验研究.工业水处理,1988,8(1):27-31
    [3] 刘晶,刘福强,李兰娟,等.新型高效氟吸附剂的研究进展.化工环保,2011,31(4):313-317 Liu Jing,Liu Fuqiang,Li Lanjuan,et al.Progresses in research on novel high-efficiency fluorin adsorbents.Environmental Protection of Chemical Industry,2011,31(4):313-317(in Chinese)
    [4] 纪兰,古映莹.石灰一聚合硫酸铁法处理含氟废水.湖南有色金属,1997,13(1):43-44
    [5] 赵艳锋,林罡明,李东泽.粉煤灰处理含氟废水的研究.科学技术与工程,2011,11(10):2389-2391 Zhao Yanfeng,Lin Gangming,Li Dongze.Study on removal of fluoride wastewater by fly ash.Science Technology and Engineering,2011,11(10):2389-2391(in Chinese)
    [6] 张昕,塔娜.沸石在污水处理中的应用研究进展.工业水处理,2011,31(7):13-17 Zhang Xin,Ta Na.Research progress in the application of zeolite to wastewater treatment.Industrial Water Treatment,2011,31(7):13-17(in Chinese)
    [7] 田奇峰,孙杰.茶叶对氟的吸附研究.化学与生物工程,2011,28(4):29-31 Tian Qifeng,Sun Jie.Study on the adsorption of fluorine by tea.Chemistry & Bioengineering,2011,28(4):29-31(in Chinese)
    [8] 王昶,季璇,徐永为,等.改性粘土对氟的吸附研究.水处理技术,2010,36(10):48-52 Wang Chang,Ji Xuan,Xu Yong,et al.Study on adsorption of fluorine by modified clay.Technology of Water Treatment,2010,36(10):48-52(in Chinese)
    [9] 徐金兰,王宝泉,王志盈,等.石灰沉淀一混凝沉淀处理含氟废水的试验.水处理技术,2003,29(5):282-285 Xu Jinlan,Wang Baoquan,Wang Zhiying,et al.Treatment of wastewater-containing fluoride by lime-sedimentation and coagulation precipitation.Technology of Water Treatment,2003,29(5):282-285(in Chinese)
    [10] 张焕祯,王振川,赵韵琪,等.石灰一CaCl2:絮凝法处理酸性高氟废水的试验研究.环境工程,1995,13(1):8-10 Zhang Huanzhen,Wang Zhenchuan,Zhao Yunqi,et al.Reseanches on the method using lime-cascium chlorite coagulation to treat acid hid high fluorine wastewatar.Environmental Engineering,1995,13(1):8-10(in Chinese)
    [11] 周武超,付权锋,张运武等.含氟废水处理技术的研究进展.化学推进剂与高分子材料,2013,11(1):45-50 Zhou Wuchao,Fu Quanfeng,Zhang Yunwu,et al.Research progress in treatment technology of fluorine-containing wastewater.Chemical Propellant & Macromolecular Material,2013,11(1):45-50(in Chinese)
    [12] Aldaco R.,Garea A.,Irabien A.Calcium fluoride recovery from fluoride wastewater in a fluidized bed reactor.Water Research,2007,41(4):810-818
    [13] 张欣露,孙新华,于宝青.含氟混合酸制取氟化钙的研究.无机盐工业,2011,43(6):59-61 Zhang Xinlu,Sun Xinhua,Yu Baoqing.Preparation of calcium fluoride by fluorine-containing mixed acid.Inorganic Salt Industry,2011,43(6):59-61(in Chinese)
    [14] 姚艳,杨道武,刘义,等.石灰乳-聚合氯化铝处理高含氟废水的研究.工业水处理,2011,31(8):42-44 Yao Yan,Yang Daowu,Liu Yi,et al.Study on the treatment of highly concentrated fluoride-containing wastewater with lime milk-polyaluminum chloride.Industrial Water Treatment,2011,31(8):42-44(in Chinese)
    [15] 杨际幸,杨天足,张杜超,等.CaCl2一PAC絮凝法处理含氟废水处理的研究.湖南有色金属,2011,27(2):53-56 Yang Jixing,Yang Tianzu,Zhang Duchao,et al.Study on fluoride removal from fluoride-containing wastewater using calcium chloride and PAC.Hunan Nonferrous Metals,2011,27(2):53-56(in Chinese)
    [16] 刘宏江,李鹏,贺军四,等.含氟废水处理的机理和工艺流程的研究.铜业工程,2012,(6):81-84. Liu Hongjiang,Li Peng,He Junsi,et al.Brief analysis on industrial security & protection system.Copper Engineering,2012,(6):81-84(in Chinese)
  • 加载中
WeChat 点击查看大图
计量
  • 文章访问数:  3374
  • HTML全文浏览数:  2699
  • PDF下载数:  919
  • 施引文献:  0
出版历程
  • 收稿日期:  2014-03-27
  • 刊出日期:  2015-04-03
杜敏, 宁静恒, 杨道武, 房文婷, 雷杰, 刘弟. CaCl2-PAC工艺处理酸性高氟废水[J]. 环境工程学报, 2015, 9(4): 1837-1841. doi: 10.12030/j.cjee.20150451
引用本文: 杜敏, 宁静恒, 杨道武, 房文婷, 雷杰, 刘弟. CaCl2-PAC工艺处理酸性高氟废水[J]. 环境工程学报, 2015, 9(4): 1837-1841. doi: 10.12030/j.cjee.20150451
shu
Du Min, Ning Jingheng, Yang Daowu, Fang Wenting, Lei Jie, Liu Di. Treatment of acidic and highly concentrated fluoride wastewater using calcium chloride-poly aluminum chloride[J]. Chinese Journal of Environmental Engineering, 2015, 9(4): 1837-1841. doi: 10.12030/j.cjee.20150451
Citation: Du Min, Ning Jingheng, Yang Daowu, Fang Wenting, Lei Jie, Liu Di. Treatment of acidic and highly concentrated fluoride wastewater using calcium chloride-poly aluminum chloride[J]. Chinese Journal of Environmental Engineering, 2015, 9(4): 1837-1841. doi: 10.12030/j.cjee.20150451
shu

CaCl2-PAC工艺处理酸性高氟废水

  • 1. 长沙理工大学化学与生物工程学院, 长沙 410114
  • 收稿日期:  2014-03-27
基金项目:

湖南省重大科技专项资助项目(2009FJ1009-3)

湖南省科技项目资助项目(2008GK3063,2010GK2043)

摘要: 以湖南某氟化盐厂排放的酸性高氟废水为研究对象,提出CaCl2-PAC处理酸性高氟废水新工艺,确定了最佳工艺条件,并对比了晶种添加前后对除氟效果、沉渣含水率的影响及沉渣中氟化钙的纯度;结果表明:在钙盐沉淀阶段, pH≈9, n (Ca/F)=0.75,搅拌45 min、沉降90 min;在絮凝沉淀阶段,pH≈7.5,PAC投加量为350 mg/L,最后出水氟离子浓度可降至10 mg/L以下,达到了《污水综合排放标准(GB8978-1996)》的一级标准。在钙盐沉淀阶段按照10 g/L添加大颗粒氟化钙后,氟去除率进一步提高,处理后所得的沉渣氟化钙纯度可达到85%,沉渣含水率较晶种添加前降低20%,有利于实现高效除氟和氟化钙的回收利用。

English Abstract

    全文HTML

参考文献 (16)

返回顶部

目录

/

返回文章
返回

Copyright © 2019 中国科学院生态环境研究中心