高级搜索

钢渣催化剂处理难降解有机废水

,  , 

downloadPDF

上一篇

下一篇

尹述伟, 高博, 陈向明. 钢渣催化剂处理难降解有机废水[J]. 环境工程学报, 2016, 10(4): 1853-1856. doi: 10.12030/j.cjee.20160443
引用本文: 尹述伟, 高博, 陈向明. 钢渣催化剂处理难降解有机废水[J]. 环境工程学报, 2016, 10(4): 1853-1856. doi: 10.12030/j.cjee.20160443
shu
Yin Shuwei, Gao Bo, Chen Xiangming. Treatment of non-degradable organic wastewater with steel slag catalyst[J]. Chinese Journal of Environmental Engineering, 2016, 10(4): 1853-1856. doi: 10.12030/j.cjee.20160443
Citation: Yin Shuwei, Gao Bo, Chen Xiangming. Treatment of non-degradable organic wastewater with steel slag catalyst[J]. Chinese Journal of Environmental Engineering, 2016, 10(4): 1853-1856. doi: 10.12030/j.cjee.20160443
shu

钢渣催化剂处理难降解有机废水

  • 1.

    武汉武新新型建材有限公司, 武汉 430080

  • 基金项目:

  • 中图分类号: X703

Treatment of non-degradable organic wastewater with steel slag catalyst

  • 1.

    Wuhan Wuxin Materials Company Limited, Wuhan 430080, China

  • Fund Project:

  • 摘要: 采用武钢钢渣粉作为催化剂,过氧化氢作为氧化剂对武钢焦化废水进行降解处理。研究表明,钢渣粉用量为15 g/L,过氧化氢浓度为80 mmol/L,在室温下反应15 min,COD去除率达到90%,达到污水排放Ⅰ级标准。随着钢渣粉用量和过氧化氢浓度的增加,催化体系对焦化废水的降解效果均呈先上升后下降的变化规律。升温有利于对焦化废水的催化降解,催化体系在不同的pH值下都比较稳定。
    Abstract: Wastewater from WISCO's coking plant was degraded with WISCO's steel slag as a catalyst, and hydrogen peroxide as an oxidant. The results showed that the chemical oxygen demand (COD) removal rate of wastewater was 90%, which can meet the first category integrated wastewater discharge standard, while the concentration of steel slag was 15 g/L, and the concentration of hydrogen peroxide was 80 mmol/L, which was treated for 15 min at room temperature. The degrading efficiency to coking wastewater of the catalytic system increased and then decreased with an increase in the amount of steel slag; it also showed the same trend in the concentration of hydrogen peroxide. The higher the treatment temperature, the better the efficiency of the catalytic system, and the catalytic system was stable to the pH value.
  • 加载中
  • [1] 周红,林海,丁浩,等.印染废水处理技术的研究现状与展望.中国非金属矿工业导刊,2007(1):60-62 Zhou Hong,Lin Mei,Ding Hao,et al.Research status and prospect of treatment technology for printing and dyeing waste water.China Non-Metallic Minerals Industry,2007(1):60-62(in Chinese)
    [2] 陈菊香,谢寒.深度处理印染废水的研究进展.科技信息,2011(35):21-25 Chen Juxiang,Xie Han.Research progress on the deep treatment of printing and dyeing wastewater.Science & Technology Information,2011(35):21-25(in Chinese)
    [3] 刘伟,游海,姚嫚,等.AO和OAO工艺对焦化废水处理效果的比较.燃料与化工,2012,43(1):55-58 Liu Wei,You Hai,Yao Man,et al.Comparison of AO and OAO processes on coking effluent treatment effect.Fuel & Chemical Processes,2012,43(1):55-58(in Chinese)
    [4] 蔡建,吴恒喜,肖建军,等.HSB高效菌种在焦化废水处理中的应用.武钢技术,2009,47(3):5-7 Cai Jian,Wu Hengxi,Xiao Jianjun,et al.Application of high solution bacteria in coking wastewater treatment.Wisco Technology,2009,47(3):5-7(in Chinese)
    [5] 高凤华.A2O法处理焦化废水的成本分析和控制.煤化工,2012,40(2):55-57 Gao Fenghua.Cost analysis and control of the A2O coking wastewater treatment.Coal Chemical Industry,2012,40(2):55-57(in Chinese)
    [6] 蒋学彬,陈漫,刘海龙,等.Fenton试剂在钻井废水处理中的应用.钻采工艺,2011,34(1):77-80 Jiang Xuebin,Chen Man,Liu Hailong,et al.Application of Fenton reagent oxidization in drilling wastewater disposal.Drilling & Production Technology,2011,34(1):77-80(in Chinese)
    [7] 窦晓文,林小琴,张华灵,等.非均相Fenton法降解水中橙黄G的研究.安徽农业科学,2011,39(9):5187-5190 Dou Xiaowen,Lin Xiaoqin,Zhang Hualing,et al.Degradation of orange G in aqueous solution by heterogeneous Fenton process.Journal of Anhui Agricultural Sciences,2011,39(9):5187-5190(in Chinese)
    [8] 赵寿春,吴柳明,尹贻芬.炼钢粉尘酸浸液-Fenton法降解亚甲基蓝.济南大学学报(自然科学版),2009,23(1):34-37 Zhao Shouchun,Wu Liuming,Yin Yifen.Degradation of methylene blue by acidic leaching solution of steelmaking flue dust-Fenton method.Journal of Jinan University (Science and Technology),2009,23(1):34-37(in Chinese)
    [9] 任奇,王颖杰,李双林.钢渣处理与综合利用技术.钢铁研究,2012,40(1):54-57 Ren Qi,Wang Yingjie,Li Shuanglin.Technologies of steel slag treatment and comprehensive utilization of resources.Research on Iron & Steel,2012,40(1):54-57(in Chinese)
    [10] 董春娟,翟伟,冯美荣.硅藻土-颗粒污泥协同处理焦化废水研究.南京理工大学学报,2013,37(5):766-771 Dong Chunjuan,Zhai Wei,Feng Meirong,et al.Coordinated treatment of actual coking wastewater with diatomite and granular sludge.Journal of Nanjing University of Science and Technology,2013,37(5):766-771(in Chinese)
    [11] 易诚,湛含辉,程胜高.混凝好氧颗粒污泥的絮凝剂选择.环境工程学报,2014,8(10):4097-4104 Yi Cheng,Zhan Hanhui,Cheng Shenggao.Selection of flocculants for coagulation of aerobic granular sludge.Chinese Journal of Environmental Engineering,2014,8(10):4097-4104(in Chinese)
    [12] 杜琳,王增长.超临界水氧化法处理焦化废水的研究.陕西科技大学学报,2011,29(2):49-50 Du Lin,Wang Zengzhang.Study on treatment of the coking plant wastewater by supercritical water oxidation process.Journal of Shaanxi University of Science & Technology,2011,29(2):49-50(in Chinese)
    [13] 雷庆铎,刘依林,谷启源,等.电催化氧化预处理焦化废水的实验研究.工业水处理,2014,34(4):51-54 Lei Qingduo,Liu Yilin,Gu Qiyuan,et al.Experimental research on the pretreatment of coking wastewater by electro-catalytic oxidation.Industrial Water Treatment,2014,34(4):51-54(in Chinese)
    [14] 张伟,刘丽华,郑睿,等.Fenton氧化-微滤处理焦化废水及膜污染机理研究.膜科学与技术,2014,34(1):104-110 Zhang Wei,Liu Lihua,Zheng Rui,et al.Fenton oxidation and microfiltration for coking wastewater treatment and membrane fouling mechanism.Membrane Science and Technology,2014,34(1):104-110(in Chinese)
    [15] 雷庆铎,赵艳霞,吴根,等.生物浮动床处理焦化废水的启动研究.工业水处理,2013,33(10):48-51 Lei Qingduo,Zhao Yanxia,Wu Gen,et al.Research on the start-up of MBBR for the treatment of wastewater from coke plants.Industrial Water Treatment,2013,33(10):48-51(in Chinese)
    [16] 王晓星,张惠灵,戢伟,等.絮凝-微波诱导氧化联合工艺对焦化废水的处理.工业安全与环保,2014,40(4):15-17 Wang Xiaoxing,Zhang Huiling,Ji Wei,et al.Treatment of coking wastewater by flocculation-microwave induced oxidation.Industrial Safety and Environmental Protection,2014,40(4):15-17(in Chinese)
    [17] 冯壮壮,王海东,于建,等.电催化氧化深度处理焦化废水的效果及能耗研究.工业水处理,2013,33(4):61-64 Feng Zhuangzhuang,Wang Haidong,Yu Jian,et al.Study on the efficacy and energy consumption of the advanced treatment of coking wastewater by electro-catalytic oxidation.Industrial Water Treatment,2013,33(4):61-64(in Chinese)
    [18] 任源,韦朝海,吴超飞,等.焦化废水水质组成及其环境学与生物学特性分析.环境科学学报,2007,27(7):1094-1100 Ren Yuan,Wei Chaohai,Wu Chaofei,et al.Environmental and biological characteristics of coking wastewater.Acta Scientiae Circumstantiae,2007,27(7):1094-1100(in Chinese)
  • 加载中
WeChat 点击查看大图
计量
  • 文章访问数:  2172
  • HTML全文浏览数:  1874
  • PDF下载数:  815
  • 施引文献:  0
出版历程
  • 收稿日期:  2015-01-12
  • 刊出日期:  2016-04-15
尹述伟, 高博, 陈向明. 钢渣催化剂处理难降解有机废水[J]. 环境工程学报, 2016, 10(4): 1853-1856. doi: 10.12030/j.cjee.20160443
引用本文: 尹述伟, 高博, 陈向明. 钢渣催化剂处理难降解有机废水[J]. 环境工程学报, 2016, 10(4): 1853-1856. doi: 10.12030/j.cjee.20160443
shu
Yin Shuwei, Gao Bo, Chen Xiangming. Treatment of non-degradable organic wastewater with steel slag catalyst[J]. Chinese Journal of Environmental Engineering, 2016, 10(4): 1853-1856. doi: 10.12030/j.cjee.20160443
Citation: Yin Shuwei, Gao Bo, Chen Xiangming. Treatment of non-degradable organic wastewater with steel slag catalyst[J]. Chinese Journal of Environmental Engineering, 2016, 10(4): 1853-1856. doi: 10.12030/j.cjee.20160443
shu

钢渣催化剂处理难降解有机废水

  • 1. 武汉武新新型建材有限公司, 武汉 430080
  • 收稿日期:  2015-01-12
基金项目:

摘要: 采用武钢钢渣粉作为催化剂,过氧化氢作为氧化剂对武钢焦化废水进行降解处理。研究表明,钢渣粉用量为15 g/L,过氧化氢浓度为80 mmol/L,在室温下反应15 min,COD去除率达到90%,达到污水排放Ⅰ级标准。随着钢渣粉用量和过氧化氢浓度的增加,催化体系对焦化废水的降解效果均呈先上升后下降的变化规律。升温有利于对焦化废水的催化降解,催化体系在不同的pH值下都比较稳定。

English Abstract

    全文HTML

参考文献 (18)

返回顶部

目录

/

返回文章
返回

Copyright © 2019 中国科学院生态环境研究中心