高级搜索

污泥-秸秆基活性炭的制备及其对渗滤液COD的吸附

,  ,  ,  , 

downloadPDF

上一篇

下一篇

何莹, 舒威, 廖筱锋, 尤太阳, 廖利. 污泥-秸秆基活性炭的制备及其对渗滤液COD的吸附[J]. 环境工程学报, 2015, 9(4): 1663-1669. doi: 10.12030/j.cjee.20150423
引用本文: 何莹, 舒威, 廖筱锋, 尤太阳, 廖利. 污泥-秸秆基活性炭的制备及其对渗滤液COD的吸附[J]. 环境工程学报, 2015, 9(4): 1663-1669. doi: 10.12030/j.cjee.20150423
shu
He Ying, Shu Wei, Liao Xiaofeng, You Taiyang, Liao Li. Preparation of sludge-stalk based activated carbon and its adsorption of COD in leachate[J]. Chinese Journal of Environmental Engineering, 2015, 9(4): 1663-1669. doi: 10.12030/j.cjee.20150423
Citation: He Ying, Shu Wei, Liao Xiaofeng, You Taiyang, Liao Li. Preparation of sludge-stalk based activated carbon and its adsorption of COD in leachate[J]. Chinese Journal of Environmental Engineering, 2015, 9(4): 1663-1669. doi: 10.12030/j.cjee.20150423
shu

污泥-秸秆基活性炭的制备及其对渗滤液COD的吸附

  • 1.

    华中科技大学环境科学与工程学院, 武汉 430074

  • 基金项目:

    "十二五"国家科技支撑计划项目(2012BAC18B02)

  • 中图分类号: X703

Preparation of sludge-stalk based activated carbon and its adsorption of COD in leachate

  • 1.

    College of Environmental Science and Engineering, Huazhong University of Science and Technology, Wuhan 430074, China

  • Fund Project:

  • 摘要: 以市政污泥与玉米秸秆为原料,采用化学活化法热解制备污泥-秸秆基活性炭,研究其物化性质、热解动力学特性及对渗滤液中COD的吸附性能。考察吸附剂投加量、吸附时间和溶液pH对COD去除率的影响,并用吸附等温线对吸附数据进行了拟合。结果表明,秸秆比例越高,活性炭的吸附碘值和BET比表面积越大,最大可达663 mg/g和902 m2/g;活性炭表面呈不规则的多孔状;秸秆比例为45%的活性炭在最佳实验条件下对COD的吸附去除率为82%;活性炭对COD的吸附符合Langmuir和Freundlich等温模型。
    Abstract: Municipal sludge and corn stalk were used to prepare sludge-stalk based activated carbon by pyrolysis with chemical methods.The physical and chemical properties,pyrolytic kinetic characteristic and adsorption characteristics of COD in leachate were studied.The effects of adsorbent dosage,adsorption time and solution pH on COD removal were discussed and the adsorption isotherms were fitted.The results showed that the higher the proportion of stalk in activated carbon,the greater the iodine value and the BET surface area,which can up to 663 mg/g and 902 m2/g;the surface of carbon was irregular and porous;the COD removal rate of activated carbon with 45% stalk added was 82%.The adsorption experimental data were fitted by both Langmuir and Freundlich isotherm models.
  • 加载中
  • [1] 石太宏,陈坚,温颖宏,等.污泥活性炭的制备及其用于重金属废水处理的研究进展.给水排水,2009,329(S1):288-292 Shi Taihong,Chen Jian,Wen Yinghong,et al.Research advance of heavy metal adsorption by activated carbon prepared from municipal sludge.Water & Wastewater Engineering,2009,329(S1):288-292(in Chinese)
    [2] 周品,谷麟,饶姗姗,等.秸秆-污泥复合基活性炭的制备及其对1,2,4-酸氧体的吸附特性.环境化学,2013,32(1):106-111 Zhou Pin,Gu Lin,Rao Shanshan,et al.Preparation of sludge-straw based actived carbon and its adsorption for 1-diazo-2-naphtol-4-sulfonic acid.Environmental Chemistry,2013,32(1):106-111(in Chinese)
    [3] Huang Wenhai,Chen Baoliang.Interaction mechanisms of organic contaminants with burned straw ash charcoal.Journal of Environmental Sciences,2010,22(10):1586-1596
    [4] 郭斌,李旭光,刘仁平,等.城市污泥混掺小麦秸秆制备活性炭的研究.热能动力工程,2011,26(6):764-767 Guo Bin,Li Xuguang,Liu Renping,et al.Research on preparation of activated carbon by sewage sludge mixed with wheat straw.Journal of Engineering for Thermal Energy and Power,2011,26(6):764-767(in Chinese)
    [5] 殷志源,张双全,范恒亮,等.城市污泥与玉米秸秆共热解及炭粉吸附特性研究.可再生能源,2011,29(2):74-77 Yin Zhiyuan,Zhang Shuangquan,Fan Hengliang,et al.Research on co-pyrolysis of sewage sludge and corn stalk and the adsorption performance of carbon powder.Renewable Energy Resources,2011,29(2):74-77(in Chinese)
    [6] 张双全,武娜,董明建,等.城市污泥与玉米秸秆共热解制备吸附剂的研究.中国矿业大学学报,2011,40(05):799-803 Zhang Shuangquan,Wu Na,Dong Mingjian,et al.Research on preparation of adsorbents by co-pyrolysis of sewage sludge with corn straw.Journal of China University of Mining & Technology,2011,40(05):799-803(in Chinese)
    [7] Rivas F.J.,Beltran F.,Carvalho F.,et al.Study of different integrated physical-chemical + adsorption processes for landfill leachate remediation.Industrial & Engineering Chemistry Research,2005,44(8):2871-2878
    [8] Rivas F.J.,Beltrán F.J.,Gimeno O.,et al.Adsorption of landfill leachates onto activated carbon:Equilibrium and kinetics.Journal of Hazardous Materials,2006,131(1-3):170-178
    [9] Rodríguez J.,Castrillón L.,Maránon E.,et al.Removal of non-biodegradable organic matter from landfill leachates by adsorption.Water Research,2004,38(14-15):3297-3303
    [10] Yu Lanlan,Zhong Qin.Preparation of adsorbents made from sewage sludges for adsorption of organic materials from wastewater.Journal of Hazardous Materials,2006,137(1):359-366
    [11] Boehm H.P.Some aspects of the surface chemistry of carbon blacks and other carbons.Carbon,1994,32(5):759-769
    [12] 李道静,封莉,张立秋.玉米芯掺杂对污泥基活性炭性能的影响.环境工程学报,2012,6(3):1010-1014 Li Daojing,Feng Li,Zhang Liqiu.Effects of corncob addition on properties of sludge activated carbon.Chinese Journal of Environmental Engineering,2012,6(3):1010-1014(in Chinese)
    [13] 立本英机,安部郁夫.活性炭的应用技术.高尚愚译.南京:东南大学出版社,2002
    [14] Ros A.,Montes-Moran M.A.,Fuente E.,et al.Dried sludges and sludge-based chars for H2S removal at low temperature:Influence of sewage sludge characteristics.Environmental Science & Technology,2006,40(1):302-309
    [15] Sing K.S.W.Reporting physisorption data for gas/solid systems with special reference to the determination of surface area and porosity (Recommendations 1984).Pure and Applied Chemistry,1985,57(4):603-619
    [16] 陈永,周柳江,洪玉珍.椰壳纤维基高比表面积中孔活性炭的制备.新型炭材料,2010,25(2):151-155 Chen Yong,Zhou Liujiang,Hong Yuzhen.Preparation of high-surface-area activated carbon from coconut shell fibers.New Carbon Materials,2010,25(2):151-155(in Chinese)
    [17] Tamai H.,Yoshida T.,Sasaki M.,et al.Dye adsorption on mesoporous activated carbon fiber obtained from pitch containing yttrium complex.Carbon,1999,37(6):983-989
    [18] 黄伟,贾艳秋,孙盛凯.活性炭及其改性研究进展.化学工业与工程技术,2006,27(5):39-44 Huang Wei,Jia Yanqiu,Sun Shengkai.Research advance of active carbon and its modification.Journal of Chemical Industry & Engineering,2006,27(5):39-44(in Chinese)
    [19] 张自杰,林荣忱,金儒霖.排水工程下册(第4版).北京:中国建筑工业出版社,2000:541
    [20] 陈小亮,谷麟,王艳,等.污泥焚烧残渣水热合成NaP1型沸石和水钙沸石的性质研究.环境化学,2011,30(12):2092-2098 Chen Xiaoliang,Gu Lin,Wang Yan,et al.Hydrothermal synthesis and characterization of nap1 zeolite and gisomdine from sludge incineration ash.Environmental Chemistry,2011,30(12):2092-2098(in Chinese)
  • 加载中
WeChat 点击查看大图
计量
  • 文章访问数:  2604
  • HTML全文浏览数:  1997
  • PDF下载数:  929
  • 施引文献:  0
出版历程
  • 收稿日期:  2014-05-04
  • 刊出日期:  2015-04-03
何莹, 舒威, 廖筱锋, 尤太阳, 廖利. 污泥-秸秆基活性炭的制备及其对渗滤液COD的吸附[J]. 环境工程学报, 2015, 9(4): 1663-1669. doi: 10.12030/j.cjee.20150423
引用本文: 何莹, 舒威, 廖筱锋, 尤太阳, 廖利. 污泥-秸秆基活性炭的制备及其对渗滤液COD的吸附[J]. 环境工程学报, 2015, 9(4): 1663-1669. doi: 10.12030/j.cjee.20150423
shu
He Ying, Shu Wei, Liao Xiaofeng, You Taiyang, Liao Li. Preparation of sludge-stalk based activated carbon and its adsorption of COD in leachate[J]. Chinese Journal of Environmental Engineering, 2015, 9(4): 1663-1669. doi: 10.12030/j.cjee.20150423
Citation: He Ying, Shu Wei, Liao Xiaofeng, You Taiyang, Liao Li. Preparation of sludge-stalk based activated carbon and its adsorption of COD in leachate[J]. Chinese Journal of Environmental Engineering, 2015, 9(4): 1663-1669. doi: 10.12030/j.cjee.20150423
shu

污泥-秸秆基活性炭的制备及其对渗滤液COD的吸附

  • 1. 华中科技大学环境科学与工程学院, 武汉 430074
  • 收稿日期:  2014-05-04
基金项目:

"十二五"国家科技支撑计划项目(2012BAC18B02)

摘要: 以市政污泥与玉米秸秆为原料,采用化学活化法热解制备污泥-秸秆基活性炭,研究其物化性质、热解动力学特性及对渗滤液中COD的吸附性能。考察吸附剂投加量、吸附时间和溶液pH对COD去除率的影响,并用吸附等温线对吸附数据进行了拟合。结果表明,秸秆比例越高,活性炭的吸附碘值和BET比表面积越大,最大可达663 mg/g和902 m2/g;活性炭表面呈不规则的多孔状;秸秆比例为45%的活性炭在最佳实验条件下对COD的吸附去除率为82%;活性炭对COD的吸附符合Langmuir和Freundlich等温模型。

English Abstract

    全文HTML

参考文献 (20)

返回顶部

目录

/

返回文章
返回

Copyright © 2019 中国科学院生态环境研究中心